Nail pops in new construction

Are nail pops serious?

Fortunately, popped nails (also known as “ nail pops ”) aren’t too tough to fix and typically aren’t serious —although there are a few exceptions. Keep reading to understand the causes of nail pops , the problems they could represent, and how you can achieve perfectly smooth walls.

Are nail pops covered by Nhbc?

This is a breach of NHBC Standards. The NHBC rely on BS5492 and this says if correct materails are used nail popping or blowing will not occur.

How do I fix nail pops in drywall?

Fill the damaged area and the holes left by the new screws with lightweight patching compound. Use a flexible putty knife to apply the compound and smooth it. Apply two or three coats, allowing each to dry completely before recoating. Popped drywall nails and screws are common in old and new homes alike.

What are nail pops?

Nail pops are the small circles that protrude from the drywall of your walls and ceiling. Usually, the nail heads and bulges do not protrude very far: just about 1/8-inch. Often they crack the paint around them.

Are nail pops normal?

Unfortunately, they’re quite normal — and even should be anticipated. Nail pops , the condition where a nail either pops through the drywall surface or is pulled deeper into the drywall leaving a depression, are, like many drywall problems, often the result of rough framing-lumber shrinkage.

Why do nail pops keep coming back?

A nail pop can occur for a variety of reasons, but typically it is due to movement. Either the drywall moved and the nail stayed still , or the nail moved and the drywall stayed still . Not many people are aware that you cannot just cover up a nail head with some spackling compound or plaster to repair the damage.

You might be interested:  Coronado springs resort construction

Why are the drywall screws popping out?

Screws typically pop out of drywall for one of two reasons: they were installed too deep, or the studs have expanded and contracted. If you drive a screw too deep through the drywall and into the stud, it may pop out . In a dry environment, studs will release moisture, causing them to contract.

How do you stop nail pops in drywall?

Control your environment: Store your drywall onsite in the home. Turn on the HVAC system during this time so that the drywall can acclimate to the home’s environment. Test your drywall to ensure that the moisture content is around 14% with the framing less before hanging. Keep humidity low while taping.

How far apart should screws be in drywall?

12 to 16 inches

How much does it cost to fix nail pops?

The most expensive part of the project is the labor. For minor repairs, expect to pay an average of $60 to $90 per hour for handyman repair , or about $50 to 75 per square foot. To make DIY repairs, the price of materials comes to around $45 for a job requiring only one 4 by 8 foot sheet of drywall.

Are screw pops common?

It is not uncommon to have a dozen screw pops out of the 25,000 — 35,000 screws in an average house. After a full year cycle of seasons and wood movement, a few more screws may pop , and the owners usually ignore them until it is time to paint the walls again. Screw pops are not usually a problem.